Smoking-Meat.com is supported by its readers. We may earn an affiliate commission at no extra cost to you if you buy through a link on this page.

Read this article without ads

Words cannot describe how good and how unhealthy this bacon wrapped sausage fatty is. Eat moderately to stay healthy, but you do need to try this.

I stuffed this one full of cheese and ham, and boy was it cheesy and delicious with every bite!

  • Prep Time: 45 minutes

  • Cook Time: 3 hours

  • Smoker Temp: 225-240°F

  • Meat Finish Temp: 160°F

  • Recommended Wood: Oak or Pecan

  • 2 lbs ground breakfast sausage (Jimmy Deans, JC Potter, etc.)

  • 1 lb original or thin sliced bacon (16 slices approx.)

  • ½ lb ham, diced into quarter inch pieces

  • 1.5 cups sharp cheddar, grated

  • Jeff’s original rub

  • Jeff’s original barbecue sauce

  • Foil and/or wax paper

This is one of those things that looks difficult but it’s really not, so don’t be discouraged before you even begin.

You can do this!

Start by laying about 8 pieces of bacon horizontally on a piece of foil that is 3-4 inches wider and longer than the expected bacon weave. I normally use a piece that is about 18″ x 24″.

IMG_9830-250x167

To make a weave, fold back every other piece on the right side about 1 inch, starting with the second one.

IMG_9831-250x167

Lay a strip of bacon vertically all the way to the right.

IMG_9832-250x167

Then the pieces that got folded back, go back to where they were.

IMG_9833-250x167

Next, we will once again fold back every other strip of bacon on the right side, only this time we’ll begin with the first one.

IMG_9834-250x167

Lay another strip of bacon vertically on the right side butted up against the first one.

IMG_9835-250x167

The pieces that got folded back, go back to where they were.

You continue this process until you have a bacon weave that is 8 slices by 8 slices or one that equals 12 inches by 12 inches approximately.

This is how it looks when you are finished:

IMG_9852-250x167

Apply a healthy portion of Jeff’s original rub to the top side of the bacon to finish off the weave.

IMG_9879-250x167

Once the weave is complete, slide the foil or wax paper that the weave is sitting on, onto a baking sheet, and place it in the fridge while you roll out the sausage.

The cold fridge will help to firm up the bacon and make it easier to work with.

I used JC Potter Hot, but you can use another flavor if you like.

IMG_9853-250x167

Remove the wrapper from the sausage chubs.

IMG_9867-250x167

Place the sausage into a gallon sized zip top bag.

IMG_9868-250x167

Flatten the sausage with your hands.

Make sure the thickness is as uniform as possible.

If you get air bubbles, you can snip the corners of the bag or leave it slightly unzipped at the top to help expel the trapped air.

IMG_9869-250x167

Now it’s time to remove the top layer of the bag.

Snip the corners of the zipper, and then use kitchen shears or scissors to cut along the seam on both sides of the bag.

IMG_9871-250x167

Peel off the top layer of the bag.

IMG_9872-250x167

Cut along the bottom seam to to completely remove the top layer of plastic.

IMG_9874-250x167

Add a good, healthy sprinkling of Jeff’s original rub to the top side of the sausage.

IMG_9875-250x167

Turn the sausage 90° so the long edge is facing you.

Place about ½ lb of diced ham onto the top of the sausage. Leave about 2 inches at the bottom and top and about 1 inch on the sides.

IMG_9876-250x167

Season the ham with Jeff’s original rub.

IMG_9877-250x167

Place about 1.5 cups of shredded sharp cheddar cheese to the top of the ham.

IMG_9878-250x167

Roll the sausage into a chub using the plastic bag like a sushi rolling mat.

Tip: use your hands to push the ham and cheese back into the sausage roll if it tries to fall out of the front or sides while you are rolling it.

Carefully move the rolled sausage chub onto the top of the bacon weave.

The sausage roll will do best if you make sure it ends up about 2-3 inches from the edge of the bacon weave.

IMG_9880-250x167

Press in on the ends of the sausage to adjust the width of the roll. It is best if the bacon weave is slightly wider than the sausage roll.

I also like to pull some sausage from the ends of the roll down to seal the opening to keep the cheese and ham from falling out.

Alternatively, you could have some extra sausage ready for this purpose. Pinch it into place to seal off the ends.

Using the foil like a sushi rolling mat, wrap the shorter edge of bacon at the top around the sausage roll and then continue to roll the sausage toward you as the bacon wraps around it.

IMG_9882-250x167

When the bacon is completely wrapped around the sausage roll, roll the bacon wrapped sausage roll in the opposite direction away from you, allowing the foil to wrap around it.

This will allow us to shape the roll and to place it in the fridge to firm up.

I recommend allowing it to firm up for at least an hour before smoking it, but overnight is preferable.

The foil wrapped fatty is placed on a Weber grill pan or baking sheet and placed in the fridge ready for the smoker.

IMG_9883-250x167

When you are ready to cook, remove it from the fridge and remove the foil.

IMG_9902-250x167

Sprinkle Jeff’s original rub onto the outside of the bacon wrapped sausage chub.

IMG_9903-250x167

Setup your smoker for cooking at 225°F (107°C) using indirect heat. If your smoker uses a water pan, fill it up.

When the smoker is ready, place the bacon wrapped sausage roll directly onto the grate or you can leave it on a pan with a rack or the weber grill pan to make it easier to handle.

When the bacon wrapped sausage roll reaches 160°F (71°C) in the thickest part (about three hours), brush on a thin coat of Jeff’s original barbecue sauce and let it continue to cook in the smoker for about 10 minutes to allow the sauce to glaze.

Remove the meat from the smoker and set it on the counter to rest for 5-10 minutes.

IMG_9916-250x167

With a very sharp knife, slice the roll into pieces that are about ½ to ¾ inch thick and serve immediately.

IMG_9940-250x167

IMG_9947-250x167

Print


Description

Ground sausage stuffed with cheese, meats, vegetables and other ingredients then wrapped in bacon and smoked? In the barbecue world this has come to be known as a “Fatty” and in this recipe, I give you my ham n’ cheddar version.


  • 2 lbs ground breakfast sausage (Jimmy Deans, JC Potter, etc.)
  • 1 lb original or thin sliced bacon (16 slices approx.)
  • 1/2 lb ham, diced into quarter inch pieces
  • 1.5 cups sharp cheddar, grated
  • Jeff’s original rub
  • Jeff’s original barbecue sauce
  • Foil and/or wax paper

Cook Mode Prevent your screen from going dark


  1. Make a bacon weave with 8 horizontal strips and 8 vertical strips on a large piece of foil. It should end up being about 12 inches by 12 inches. Season the top of the bacon weave with Jeff’s original rub then place the bacon weave in the fridge to firm up.
  2. Place 2 lbs of ground sausage into a zip top bag. Flatten the sausage inside the bag until is of equal thickness. Use scissors to cut along the seams and remove the top layer of the plastic bag.
  3. Season the top of the sausage with Jeff’s original rub recipe.
  4. Lay the flattened sausage onto the bacon weave with the top edge about 3 to 4 inches from the top edge of the bacon weave. Place ½ lb of diced ham and 1.5 cups of sharp cheddar cheese onto the flattened sausage. Leave about 2 inches at the top and bottom and 1 inch on the sides.
  5. Season the ham and cheese with Jeff’s original rub recipe.
  6. Using the plastic like a sushi mat, roll the sausage and stuffing into a roll and onto the bacon weave. Seal the ends of the sausage roll with more sausage to keep the cheese and ham from falling out during the cooking process.
  7. Using the foil like a sushi mat, wrap the bacon weave around the sausage roll. Wrap the roll tightly in foil. Place the wrapped sausage roll in the fridge to firm up for at least an hour or overnight.
  8. Just before cooking, season the outside of the bacon with Jeff’s original rub.
  9. Setup your smoker for cooking at 225°F (107°C) using indirect heat. If your smoker uses a water pan, fill it up.
  10. Place the bacon wrapped sausage roll directly onto the smoker grate or use a pan with a rack or the Weber grill pan to make it easy.
  11. Cook the sausage roll for about 3 hours or until the inside of the meat reaches 160°F (71°C).
  12. Glaze the outside with Jeff’s original barbecue sauce if desired and let it continue cooking for about 10 minutes to glaze the sauce.
  13. Remove from the smoker and let it rest for 10 minutes.
  14. Slice and serve.

Order Jeff’s Rubs and Barbecue Sauce!

✅ My rubs and sauce will be the best thing you’ve ever tasted and it’s a great way to support what we do!

Order Now

Did you know? You can order the MASTER FORMULAS which allow you to make Jeff’s rubs and barbecue sauce at home using your own ingredients! Order the Recipes

© 2024 All rights reservedBuilt with Flowershow Cloud

Built with LogoFlowershow Cloud